Home made CQC rocket stove (L) is easily improved with the addition of a Jet-Flame (L).

We won the Tibbets Award!

/0 Comments/in , ,

ASAT, the for-profit arm of Aprovecho, has been awarded a prestigious Tibbetts Award by the US Small Business Administration. The Tibbets Award is given for demonstrating significant economic and social impact from the R&D funding provided by SBIR (Small Business Innovation Research) grants. ASAT received EPA SBIR grants that enabled the research and development of:

  • The Jet-Flame that increases combustion efficiency (costs around $11). See: www.Jet-Flame.com
  • An air cooled thermoelectric generator (water cooling is hard to install).
  • A low cost, easily cleaned electrostatic precipitator (90% reduction of soot).
  • The Integrated Stove. See: www.ssmstoves.com/project/m55/

We partnered with the Gates funded Global Health Lab to develop the Jet-Flame. They have recently supported sending Jet-Flame samples worldwide. C-Quest Capital (CQC) has completed several pilots and has plans to do projects in Africa, Asia, and India. A factory in Malawi is gearing up to build Jet-Flames and solar systems with carbon credits from CQC. 

Home made CQC rocket stove (L) is easily improved with the addition of a Jet-Flame (L).
The CQC home made brick Rocket stove is updated with the Jet-Flame in Malawi

“C-Quest Capital is committed to the Jet-Flame as a truly breakthrough technology. Our stoves in Malawi now use less wood, women save time cooking, and breathe a lot less smoke.”

–Ken Newcombe, CEO, C-Quest Capital

The clean combustion of biomass adds homegrown power to the energy mix here in the USA and in other countries. Without the EPA SBIR this would not have happened! To learn more about the Tibbets Award, visit tibbetsawards.com.

Chart showing how more air exchanges reduces indoor air pollution from cooking

Air Exchange Rates and the ISO Tiers of Performance

/1 Comment/in , , ,
Chart describing the influence of air exchange per hour rates on the concentration of PM2.5 in a 30 cubic meter room. Higher air exchanges equal lower PM2.5 concentrations.
Using the ISO box model, Sam Bentson has calculated how increased ventilation helps a classic Rocket stove (around 30 mg/minute of PM2.5) and a modern TLUD burning pellets (about 5mg/minute PM2.5) to protect health.

In the lab, we are used to thinking of the ISO Tiers as static, based on how much pollution enters a 30 cubic foot kitchen during four hours of cooking with 15 air exchanges per hour. However, in 2018 ISO published 19867-3 that further explains how, for example, increasing the air exchange rate (ACH) changes the Tier rating. Generally, doubling the air exchange rate cuts pollution (PM2.5 and CO) in half.

In a low ventilation situation (10 ACH), Tier 4 requires that the emissions of CO are lower than 2.2 grams per megajoule delivered to the pot (g/MJd). But in a higher ventilation condition (30 ACH) the stove can be three times dirtier, emitting up to 7 g/MJd, and still be in Tier 4. Cooking outside is often employed by the cooks we work with because smoke is bothersome and unhealthy.

ISO 19867-3 reports that studies of air exchange rates have found a lot of variation in ventilation, from 4 ACH in very tight buildings to 100 ACH outside in the fresh air. When I lived on a ranch in Mexico, most of the cooking took place outside under a veranda (which also made it easier to smell the wonderful homemade coffee brewing in the early mornings). When Sam Bentson carefully measured the ventilation rate under our veranda in Oregon he also found that when a gentle breeze was blowing (2 MPH) the air exchange rate per hour was around 100.

At 100 ACH, with so much dilution occurring outside, achieving Tier 4 for PM2.5 and CO is easier. In our experience, the most successful and cost effective interventions are situation dependent. We find that a combination of approaches to protecting health enables a welcome adaptability to the actual and interwoven circumstances.